Russian

Missiles Systems



Rocket R-5

Principal characteristics

Maximum firing range, km

Launch mass, kg

Warhead mass, kg

Propellants mass
(liquid oxygen, ethyl alcohol,
hydrogen peroxide, gas), kg

PU ground thrust, kgf

1200

28570

1425



24370

43860

Rocket R-5


For the first time, both fuel tanks of rocket R-5 were integral. Experience gained from operating rockets R-1 and R-2, as well as analysis and experiments showed that evaporation of liquid oxygen while on a launch pad and during an ascent phase were not so sizable as it was previously thought and, with a proper re-supply of the oxygen tank at a launch pad, heat shield might no longer be needed. Further, such an approach became routine for a rocket of any design using liquid oxygen in the capacity of a propellant component.
The rocket R-5 engine was provided with a special extension nozzle that enabled to increase a flight range up to 1200 km. The pressurized instrumentation compartment was removed. All control system instruments, except for sensitive elements (gyroscopic devices and integrators) were housed in a compartment being a direct continuation of the aft compartment. The sensitive elements were accommodated far from the engine, in the inter-tank section on special brackets to avoid vibration effects. In addition to the autonomous control system, range radio control, cross range radio correction, and engine emergency shutdown systems were used for the first time. The tanks were provided with vortex-free fuel intake devices to decrease fuel remainders.
Aerodynamic and heat resistance appeared to be a rather large problem. The warhead, re-entering atmosphere at a velocity of above 3000 m/s, was exposed to high temperature loads. To protect the warhead shell, application specific coatings based on sublimated (evaporating) high enthalpy materials have been developed.
Prior to carry out flight tests at the 2 NII-88 affiliate division, firing bench tests of rocket R-5 were run. The purpose was to define an actual temperature of propellants in fuel tanks, verify the control system and engine automatics functionality, verify the engine firing timeline and record its actual performance data.
Three cycles of R-5 flight tests were planned of which the first and the second cycles were experimental and the third cycle included adjustment and qualification tests.
The first cycle of R-5 flight tests has been carried out in March - May, 1953. Eight launches have been performed: two launches - to a range of 270 km, five launches - to a range of 1200 km, and one launch - to a range of 550 km. Six of eight rockets reached the destination.
The first successful launch to a maximum range took place on April 19, 1953.
While preparing for the second cycle of R-5 tests, a number of modifications were made to the rocket structure and control system.
The second cycle of R-5 tests has been run in October-December 1953. A launch range of all 7 rockets was 1185 km. One launch failed because of a damage in the onboard cabling that triggered the engine shutdown command and, consequently, resulted in the rocket undershoot.
The third cycle of R-5 flight tests took place in a period from August 1954 to February 1955. In total, 19 launches have been carried out: 5 adjustment launches, 10 qualification launches and, in addition, 4 adjustment launches were added because of failures to verify range radio control.
Rocket R-5 introduced a qualitatively new approach to designing ballistic rockets. With a 37% increase in the R-5 launch mass its firing range increased two times as compared to R-2, masses of fore bodies being practically equal. It was achieved mainly through increasing the engine specific impulse and sufficiently decreasing (by 25%) the rocket structure relative mass (without the warhead) that in many aspects demonstrated technological maturity of the rocket.

Rocket R-5M


Principal characteristics

Maximum firing range, km

Launch mass, kg

Warhead mass, kg

Propellants mass
(liquid oxygen, ethyl alcohol,
hydrogen peroxide, gas), kg

PU ground thrust, kgf

1200

28610

1300



24760

43860

Rocket R-5M


The first strategic rocket R-5M was derived from rocket R-5 in accordance with the Decree of April 19, 1954 to carry a nuclear warhead to a range of 1200 km. This work was initiated late in 1953.
There was a need to develop a new and shorter warhead to reduce two times the warhead ground-contact velocity to meet its automatics requirements.
The nuclear charge accommodated on the rocket made imperative to improve its control system reliability to avoid the whole rocket failure in the event of an error or a damage in one of the control system circuits.
It was also required to sufficiently simplify the rocket pre-launch processing, to reduce man-hours, and a number of support personnel.
It was planned to develop technology for integrated tests of two items: the rocket and its warhead accommodating a nuclear charge, as well as to work out the entire phased schedule of work to be executed at the launch site.
To enhance the R-5M reliability, all onboard circuits of the control system and the radio system were made redundant, a stabilization automatics contained two independent links, a vernier unit included not four, as all previous rockets, but six steering verniers. The control system power supply sources were provided with redundancy and a three-link integrator was used for a range control. The control system instruments used to reduce vibro effects were moved from the aft to the inter-tank compartment. In addition, a new self-destruction system was introduced in the R-5M control system. It meant that, in the event of considerable deviation of the rocket from its program trajectory accounting of any failures, it had to be destroyed in flight by means of the self-destruction system, or its flight had to be terminated through emergency shutdown of its engine. A completely automated system for the R-5M engine ignition was also incorporated.
Flight tests were two-step: manufacturer tests and flight-design tests. 13 rockets of 14 reached the destination.
The first successful launch of R-5M occurred on January 21, 1955.
On February 2, 1956 rocket R-5M carrying a real nuclear charge has been launched. Once 1200 km have been flown, the warhead reached ground in the prescribed area without destruction. An impact detonator actuated and a ground nuclear explosion took place.
On June 21, 1956 rocket R-5M entered service. In 1959, two rocket sections armed with rockets R-5M were the first among the rocket forces to go on sentries.
Rocket R-5M became the first domestic strategic rocket carrying a nuclear charge that gave start to the development of the national nuclear-rocket protection shield.

Rocket R-5M pre-launch processing Rocket R-5M engine burn Rocket R-5M pre-launch processing The recovered warhead of rocket R-5A at the fall site

Rocket R-5M served as basis for geophisical rockets R-5A, R-5B, R-5V
On February 21, 1958 the world record for the altitude of 473 km was set up on single-stage rocket R-5A that carried a payload of 1520 kg mass and recovered an object of 1350 kg mass.

Rocket R-5V on the launch pad.
The rocket had been launched till 1975 (including launches under program "Vertical")

News Archive

October  2019
Mon Tue Wed Thu Fri Sat Sun
  1 2 3 4 5 6
7 8 9 10 11 12 13
14 15 16 17 18 19 20
21 22 23 24 25 26 27
28 29 30 31